Bombardier Recreational Products Snowmobile Expedition LE 9AT

Maintenance is very important for keeping your vehicle in safe operating condition. Proper maintenance is the owner's responsibility. The vehicle should be serviced as per maintenance schedule.

The maintenance schedule does not exempt the pre-ride inspection.

WARNING: Failure to properly maintain the vehicle according to the maintenance schedule and procedures can make it unsafe to operate.

Replace spark plugs (must be replaced by an authorized Ski-Doo dealer)

Inspect oil pump strainer and clean if needed

Replace spark plugs (must be replaced by an authorized Ski-Doo dealer);

WARNING: Never operate engine with side panels opened or removed from vehicle.

Lift the rear portion of panel to free the plastic tab from the console

Recommended Fluid: Use only DOT 4 brake fluid from a sealed container. An opened container may be contaminated or may have absorbed moisture from the air.

WARNING: Use only DOT 4 brake fluid from a sealed container. To avoid serious damage to the braking system, do not use fluids other than the recommended one, nor mix different fluids for topping up.

NOTICE: Brake fluid can damage painted and plastic parts. Handle with care. Rinse thoroughly in case of spillage.

Vehicle placed on a level surface

Check brake fluid (DOT 4) in reservoir for proper level

Added fluid (DOT 4) as required

WARNING: Use only DOT 4 brake fluid from a sealed container. To avoid serious damage to the braking system, do not use fluids other than the recommended one, nor mix different fluids for topping up.

NOTICE: Brake fluid can damage painted and plastic parts. Handle with care. Rinse thoroughly in case of spillage.

Sign off on the brake fluid maintenance

Warning: Do not use a higher rated fuse.

Warning: If fuse has burnt out, source of malfunction should be determined and corrected before restarting. See an authorized Ski-Doo dealer for servicing.

Sign off on the fuse inspection

NOTICE: Whenever adjusting rear suspension, check track tension and adjust if necessary.

Stopper straps length has an effect on the amount of weight the center spring has to carry especially during acceleration, therefore on the front end uplift.

Stopper straps length also has an effect on center spring travel.

NOTICE: Always adjust both stopper straps to the same length.

Whenever stopper straps length is changed, track tension must be checked.

NOTE: Decreasing the stopper strap length may reduce comfort.

When operating the snowmobile in deep snow, it may be necessary to vary stopper strap length and/or riding position, to change the angle at which the track rides on the snow.