John Deere Tractor 6190R

Cooling system - Have the viscous fan checked by your John Deere™ dealer

Cab - Have accumulator of cab suspension checked by your John Deere™ dealer

Engine - Have glow plugs checked by your John Deere™ dealer

Engine - Have valves adjusted by your John Deere™ dealer

Front-wheel drive axle - Have accumulator of TLS changed by your John Deere™ dealer

Sign off on the 1000 Hourly Maintenance

All lights (including headlights) are functioning properly

Drain water and sediment from fuel filter

Remove trash from area surrounding the engine

Clean the radiator and condenser, fins and screens

Check the transmission/hydraulic system oil level

Check the level of oil in the engine

Lubricate lift links and rockshaft

Accumulator on TLS front-wheel drive axle

Nitrogen pressure checked by a John Deere™ dealer?

Front axle without front-wheel drive

Clean wheel hubs and apply new grease?

Replace filter on crankcase vent (oil separator)?

Transmission/hydraulic system - Steps

Access the diagnostic trouble codes, rectify fault and then delete the codes

Check the Neutral Start Circuit - AutoPowr™/ IVT™ Transmission

Check the Neutral Start Circuit - DirectDrive Transmission

PTO actuation - Check safety device

Lights - Check settings of headlights

Load center - Visual inspection, and clean

Fuel system - Drain water and sediment from fuel tank

Front axle without front-wheel drive - Tighten screws

Check that all accessible ground cables are secure

Engine - Check drive belt for wear

Engine - Change engine oil filter

Drain oil with engine shut off, but with engine oil still warm.

Fuel system - Change fuel filter

Always change the two filters at the same time.

Have brake system bled and checked by a John Deere™ dealer

Lubricate the draft link bearings (if equipped)