C Service
Performed C service - Changed all the filters, changed the oil and took a sample, checked the coolant level, greased all the grease points on the truck, checked over the front and rear brake components, checked over the front and rear suspension components, checked lights and reflectors, checked the overall cab/body condition, checked the condition of the driveline, checked the fluid levels in the transmission and differentials and front hubs, checked the condition/pressure/tread depth of the tires, checked the wipers/washer fluid, checked mirrors/windshield, checked the condition of the batteries, checked engine/compartment, checked the condition of the exhaust system, Checked 5th wheel condition and operation, Checked Steering system components/operation. Checked for fault codes
Pro Vision Transport
05/21/2025
C Service
Performed C service - Changed all the filters, changed the oil and took a sample, checked the coolant level, greased all the grease points on the truck, checked over the front and rear brake components, checked over the front and rear suspension components, checked lights and reflectors, checked the overall cab/body condition, checked the condition of the driveline, checked the fluid levels in the transmission and differentials and front hubs, checked the condition/pressure/tread depth of the tires, checked the wipers/washer fluid, checked mirrors/windshield, checked the condition of the batteries, checked engine/compartment, checked the condition of the exhaust system, Checked 5th wheel condition and operation, Checked Steering system components/operation. Checked for fault codes
Preliminary Steps
Unit Number
Odometer
Meter name
Unit
APU hours
Meter name
Unit
Date
Drive In Inspection
Start engine, check for unusual noises or smoke
Check steering wheel free play (engine running)
Check clutch operation if applicable
Check horns/instruments/accessories
Check wiper/washer operation
Check all glass and mirrors
Check seat/seatbelt/floor mats/cosmetics
Check air dryer and air governor operation
Check for air pressure leaks
Check permit book, required stickers, plate
Check low air warning device and dash valves
Service
Engine Compartment Inspection
Fill windshield washer reservoir
Check air restriction gauge
Check for exhaust leaks
Check power steering fluid
Check drag link, steering u-joints, gearbox
Check A/C components for leaks/condition
Check belts & belt driven component condition, adjustment, and alignment
Check heating tubes and hoses
Check intake system hoses & clamps
Circle Inspection
Check safety equipment & mounting
Check spare filters & belts
Check mirror and antenna mount
Check air hoses and glad hands/seals
Check trailer light cord and sockets
Check muffler, braces, and mounting
Check radiator, CAC, condenser for damage
Check all lights & reflectors
Check for physical damage
Check for outer hub leaks
Inspect & lube all door/hood hinges/latches
Drain primary air tank
Check batteries, connections, and wires
Load test batteries
Check for any fluid leaks
Drain water from fuel water separator
Inspect/lube wipers/linkage
Check fan assembly (key on), shroud, radiator
Check and adjust antifreeze protection level (-25 to -35)
Under Vehicle Inspection
Check exhaust system
Check for fluid leaks under truck
Check oil level of transmission and diff
Check trans cooler lines for leaks & clean
Check air ride suspension, springs, u-bolts
Check spring shackles & hanger brackets
Check frame and attaching members
Front End Inspection
Raise front end
Inspect for loose/noisy bearings
Check king pins
Check tie rod ends & drag link
Inspect valve stems & caps
Check tires for irregular or alignment wear
Check for cuts, tears, bulges, and nails
Check wheels for cracks or loose lug nuts
Left steer
Meter name
Unit
Left steer
Meter name
Unit
Left front outside
Meter name
Unit
Left front inside
Meter name
Unit
Left rear outside
Meter name
Unit
Left rear inside
Meter name
Unit
Right steer
Meter name
Unit
Right steer
Meter name
Unit
Right front outside
Meter name
Unit
Right front inside
Meter name
Unit
Right rear outside
Meter name
Unit
Right rear inside
Meter name
Unit
Other
Check fifth wheel mounting/condition
Check fuel tank mounting/straps/cap/lines
Check parking brake operation
Check air psi build time: 85-100psi in 45 sec
Check TPV
Replace/clean fuel tank vent filter
Brake Inspection
Check auto slack adjusters & clevis pins
Check 'S' cam and cam bushings
Check slack adjuster clevis pin/cam snap rings
Inspect condition of brake drums/rotors
Inspect condition of brake linings & wheel seals
Check brake lining to drum alignment
Inspect brake chambers, pushrods, & mounting
Check condition of all brake hoses
Inspect caliper function & mounting
Release parking brake & check for air leaks
Apply service brakes & check brake chambers, fittings, lines, components for air leaks
Record brake lining thickness
Left steer
Meter name
Unit
Record brake lining thickness
Left front drive
Meter name
Unit
Record brake lining thickness
Left rear drive
Meter name
Unit
Record brake lining thickness
Right steer
Meter name
Unit
Record brake lining thickness
Right front drive
Meter name
Unit
Record brake lining thickness
Right rear drive
Meter name
Unit
Check push rod travel of each chamber in spec
Inspector Name
Click here to sign
Signature
Click here to sign
Source: Pro Vision Transport (Community Member)